Recall 18V-248: Electronic Auxiliary Water Pump – 2007-2012 BMW

“This site contains affiliate links for which OEMDTC may be compensated”

NHTSA Campaign Number: 18V248
Manufacturer BMW of North America, LLC
Components ENGINE AND ENGINE COOLING
Potential Number of Units Affected 47,806

 

Electric Auxiliary Water Pump Failure

If the circuit board were to overheat, it can increase the risk of a fire.

 

Summary

BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.

 

Remedy

BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.

 

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

 


SI B11 05 18
Engine
November 2018
Technical Service

 

RECALL 18V-248: ELECTRONIC AUXILIARY WATER PUMP

New information provided by this revision is preceded by this symbol .

Please perform the procedure outlined in this Service Information on all affected vehicles before customer delivery. In the event the customer has already taken delivery of the vehicle, please perform the procedure the next time the vehicle is in the shop.

This Service Information bulletin replaces SI B11 05 18 dated August 2018

 

What’s New:

  • Part Number for the Alpina B7 has been updated (see Parts Information)

MODEL

Models with N63 Engine Models with S63 Engine Models with N74 Engine
5 Series (F07, F10) X5M (E70) 7 Series (F02)
6 Series (F12,F13) X6M (E71)
7 Series (F01, F02) incl. Alpina
7 Series ActiveHybrid (F04)
X5 (E70)
X6 (E71)
X6 Hybrid (E72)

 

SITUATION

The electronic circuit board of the auxiliary coolant pump could short circuit. This short circuit may cause the auxiliary water pump to overheat. In rare cases where overheating occurs, a fire in the engine compartment is possible.

 

AFFECTED VEHICLES

This Recall Campaign involves on certain Model Year 2008 – 2012 BMW vehicles with N63, S63 and N74 engines that were produced from November 2007 through November 2011.

Approximately 23,164 vehicles are affected by this recall.

Affected vehicles will show the campaign as “Open” when checked either in Warranty Vehicle Inquiry, AIR or ISPA Next and identified with the description: 0011730400 B110518 Recall: Electronic Auxiliary Coolant Pump

Affected customers will be notified in June 2018 via First Class mail.

 

PROCEDURE

Replace the auxiliary water pump for the turbochargers. Refer to Repair Instruction RA 11 53 090 Removing and installing/replacing auxiliary water pump for exhaust turbocharger (N63) for replacement of the pump and proper coolant bleeding procedures.

 

PARTS INFORMATION

Quantity Description Part Number
1 Auxiliary water pump (E72 X6 Hybrid) 11 51 7 629 913
1 Auxiliary water pump (F02 N74) 11 51 7 629 914
1 Auxiliary water pump (F04 w/N63) 11 51 7 629 915
1 Auxiliary water pump (F01, F02, F10, F07, F12, F13, E70, E71 w/N63) 11 51 7 629 916
1 Auxiliary water pump (E7X w/S63) 11 51 7 629 917
1 Auxiliary water pump (Alpina B7) 11 51 7 629 917
2 Hose clamp 11 15 1 726 339
See sublet below ANTIFREEZE 82 14 1 467 704

 

WARRANTY INFORMATION

Reimbursement for this Recall will be via normal claim entry utilizing the following information:

Defect Code: 0011730400

 

The vehicle is already in your workshop

Labor Operation: Labor Allowance: Description:
00 66 631 8 FRU (F01, F02, F07, F10, F11, F12, F13); Replace auxiliary coolant pump (Plus work)
” “ 11 FRU (F04); ” “
” “ 12 FRU (E70 S63, E71 S63); ” “
” “ 15 FRU (E70 N63, E71 N63); ” “
” “ 17 FRU (F02 N74); ” “
” “ 25 FRU (E72) ” “

 

Or:

The vehicle arrives at your workshop for this Recall repair

Labor Operation: Labor Allowance: Description:
00 66 073 9 FRU (F01, F02, F07, F10, F11, F12, F13);; Replace auxiliary coolant pump (Main work)
” “ 13 FRU (F04); ” “
” “ 13 FRU (E70 S63, E71 S63); ” “
” “ 17 FRU (E70 N63, E71 N63); ” “
” “ 19 FRU (F02 N74); ” “
” “ 26 FRU (E72) ” “

 

And:

Sublet – Bulk Materials

Sublet Code 4 Up to $10.00 Reimbursement for the repair-related bulk materials
(Do not use the part numbers for claim submission)

 

Sublet reimbursement calculation for claiming repair-related bulk materials (BMW part numbers) is at the dealer net price for the “quantities used” plus your center’s handling.

Enter this material cost in sublet and itemize the amount on the repair order and in claim comment section.

And, as applicable:

Consequential Repair(s)

When additional work and/or parts are required as a “direct result” of the issue being address in this Service Information bulletin, claim these items under the defect code listed above together with the corresponding labor operations listed in the KSD2.

Please explain the reason for this repair work (the why and what) on the repair order and in the claim comments section.

And, as applicable:

Alternative Mobility Solution (AMS) for Vehicle Owners

This Recall repair qualifies for Alternative Mobility Solution (AMS) expense reimbursement, claim this item under the Defect Code noted above as follows:

  • Sublet Code 2 – Itemize the AMS sublet amount on the repair order and in the claim comment section.

Please refer to SI B01 29 16 for additional information.

TREAD Act – Previous Customer-Pay Repairs

If your center is presented with a reimbursement request for a “qualifying customer-pay repair” that was performed on an “affected vehicle” prior to the release of this Recall Service Information bulletin, BMW of North America, LLC (“BMW NA”) will reimburse this previous repair.

Customer-pay Invoice Review and Reimbursement Procedure

  1. Review and verify that the previous customer-pay invoice (BMW center or independent repair shop) contains a repair that was performed to “address the issue” described in this “Recall” Service Information bulletin.
  2. If this prior repair qualifies, reimburse the customer (labor and parts).
  3. Submit for this customer-paid repair expense under Defect Code 85 99 00 12 NA, as follows:
    • Sublet Code “3”
    • Dollar amount (with no markup)
    • Comment: Recall Campaign 18V-248: Electronic Auxiliary Water Pump – Reimbursement for allowable expenses that relate to performing a prior qualifying customer-pay repair.
    • Itemize the sublet amount on the repair order and in the claim comments
  4. Retain the “original” customer pay invoice in your files; this documentation may be requested by BMW during the claim review process).

Note: A previously reimbursed repair, a repair performed on a non-affected vehicle, and/or, the diagnosis and repair of other “unrelated issues” on an affected or non-affected vehicles does not qualify for reimbursement.

This claim submission for the “prior customer-pay reimbursement,” when it is submitted as outlined under Defect Code “85 99 00 12 NA,” will not close the “Open” Safety Recall on the vehicle.

The applicable “open” Recall repair must still be performed on the vehicle.

 

SI B11 05 18: ALTERNATE TRANSPORTATION MEASURES (ATM)

For this recall, please use the following alternate transportation measures for those customers who have concerns about driving their affected BMW vehicle while they wait to have this safety-recall completed.

A. Enhanced Car Rental Procedure

For those customers with eligible Affected Vehicles needing mid to long-term alternate transportation car rentals, please refer to the Enhanced Car Rental Procedure option attachment for important information about:

  1. The rental car allowance;
  2. Safety-Recalled BMW_Vehicle Condition_Assessment Form; and the
  3. Self-Storage Agreement.

The following is required to be performed prior to supplying the customer the rental vehicle and submitted via the email address below within two (2) business days of supplying the rental vehicle:

  • Fully complete the attached Safety Recalled BMW Vehicle Condition/Assessment Form and if applicable, the Self-Storage Agreement (Save either as pdf or print and scan to attach to the email)
  • Create an email with the Subject: Safety Recall Rental Request – VIN: ####### (Customer’s VIN- last seven)
  • In the body of the email, please include the start date of the rental, the part number(s) that are not available and any other information that is relevant to the situation
  • Provide a center contact person’s name, phone number and email address.
  • Please send this VIN-specific email to rentalrequest@bmwna.com with the completed Safety Recalled BMW Vehicle Condition/Assessment Form and if applicable, the Self-Storage Agreement attached for review.

A BMW NA representative will respond to your e-mail with instructions on how to proceed.

B. AMP Vehicles

Subject to availability and at the discretion of your center, provide the owner/operator of an Affected Vehicle in a comparable AMP Vehicle Loaner.

Owner/Operator Self-Storage Vehicle Agreement Form

With the customer’s agreement and consent, you may allow the customer to retain and self-store their affected vehicle until the parts and/or repair procedure become available for this safety-recall.

Please print out the attached Owner/Operator Self-Storage Agreement Form and fill in the recall and customer’s information. Please have the customer read and sign this agreement.

Required Documentation

A copy of the customer’s completed and signed vehicle storage agreement form must be maintained in your center’s Vehicle History File and if necessary, be provided to BMW NA upon request.

Please, also keep copies of all the corresponding safety recall parts and/or SIB-related information and documentation, vehicle’s condition/assessment form and rental car invoices in the customer’s Vehicle History File as applicable.

Customer Escalations

If you have an escalated customer situation concerning this safety-recall, please send an e-mail to recall.customerescalations@bmwna.com for review.

Please include the customer’s name, their 17-character Vehicle Identification Number (VIN) and a brief explanation of their Safety Recall-related issue.

Safety Recall Repair Completion

As with any repair, once the corresponding safety recall-related parts and/or repair procedure become available from BMW NA, every effort must be made to immediately schedule service appointments at your center so this safety-recall repair can be performed on these vehicles.

Note: The client will have five (5) days after the safety-related recall repair (completion) date

to pick up their vehicle.

After five days, any additional time he/she remains in the rental car vehicle will be at the owner’s/operator’s expense.

 

ATM CLAIM SUBMISSION INFORMATION

Reimbursement for this specific safety-recall related car rental expenses is via normal claim entry, as a separate line item, utilizing the following information:

Defect Code: 11009999RV Rental Reimbursement – Safety-Recall Parts
Supply/Repair Procedure Issues
Sublet Code 3 Sublet at cost Reimbursement for an alternate transportation vehicle through one of our preferred third-party rental car providers

 

Mid to Long-Term Car Rentals

Due to the current part supply situation, BMW NA anticipates that some customers may require alternate transportation for thirty (30) days or more. As a result, you may have to submit more than one claim for rental car reimbursement, before your center has the parts necessary to fix an Affected Vehicle.

For these cases, BMW NA recommends that your center submit a claim for the rental car reimbursement at 30-day or monthly intervals (invoice after each 30 day or month of rental car usage); explain the situation in the claim comments; and reference the email you sent by date.

Please note: If the above Enhanced Car Rental Procedure is not adhered to and BMW NA does not receive the required email about this the rental, the corresponding claim submissions will be declined or debited.

Thank you for your continued cooperation and support.

Posted: Tuesday, November 20, 2018

 

ATTACHMENTS

View PDF attachment B110518 Recall Notice.

View PDF attachment 2018-Aux.WaterPump-QA-(23Apr2018).

View PDF attachment B110518_Safety-Recalled BMW_Vehicle Condition_Assessment Form.

View PDF attachment B110518_Vehicle Owner_Operator Self-Storage Agreement.

View PDF attachment B110518_Enhanced Car Rental Procedure.


SAFETY RECALL NOTICE

 

To:  All Center Operators, Sales Managers, Service Manager, Parts Manager and Warranty Processor

RE: Recall 18V-248: Electronic Auxiliary Water Pump B11 05 18

 

BMW Group is conducting a Voluntary Safety Recall (effective April 25, 2018) on certain Model Year 2008 – 2012 BMW vehicles with N63, S63 and N74 engines that were produced from November 2007 through November 2011. The issue involves the electric auxiliary water pump for these turbocharged engines.

 

Owners will be notified by First Class mail about the Recall and will be instructed to bring their vehicles in for a free repair when parts are available.

 

Please be reminded that it is a violation of federal law (The Safety Act) for you to sell, lease or deliver any new motor vehicle covered by this notification until the recall repair has been performed.  This means that centers may not legally deliver new motor vehicles to consumers until they are fixed or use/sell replacement equipment/parts subject to this recall.  Note also that substantial civil penalties apply to violations of the Safety Act. 

 

Also, you should not sell, lease or deliver any Certified Pre-Owned or used vehicles subject to a safety recall until the repair is completed. 

 

Please follow any special instructions that we provide to you for the return or disposition of recall parts.

  

We appreciate all your assistance with this Recall.


Electric Auxiliary Water Pump for Turbocharger
Safety Recall 18V-248
Model Year 2007-2012
BMW / MINI
Last Updated 4/23/2018

Q1. Which models are included in this Safety Recall?
Included are approximately 46,996 vehicles (BMW – 23,164 / MINI – 23,832) in the US, with approximate volumes and production dates as noted below.

BMW

Series Model Model Year Approx. Volume Production Dates
F10 550i, 550i xDrive 2011 – 2012 5,700 Apr 23, 2010 – Sep 14, 2011
F07 550i Gran Turismo, 550i Gran Turismo xDrive 2010 – 2012 687 Jul 30, 2009 – Sep 8, 2011
F13 650i Coupe, 650i xDrive Coupe 2012 495 Dec 10, 2010 – Sep 15, 2011
F12 650i Convertible, 650i xDrive Convertible 2012 2,053 Jan 12, 2011 – Oct 31, 2011
F01 / F02 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li

(including Alpina B7)

2009 – 2012 8,417 Oct 14, 2008 – Sep 13, 2011
F04 ActiveHybrid7 2011 – 2012 322 Sep 24, 2010 – Sep 6, 2011
E70 X5 xDrive50i, X5 M 2010 – 2012 3,853 Jul 3, 2009 – Nov 19, 2011
E71 X6 xDrive50i, X6M 2008 – 2012 1,614 Nov 15, 2007 – Nov 18, 2011
E72 X6 Hybrid 2010 – 2011 23 Sep 14, 2009 – Sep 12, 2011

 

MINI 

Series Model Model Year Approx. Volume Production Dates
R55 Cooper S Clubman, JCW Clubman 2008 – 2012 2,779 Jan 28, 2008 – Sep 23, 2011
R56 Cooper S, JCW 2007 – 2012 8,762 Jun 28, 2007 – Sep 23, 2011
R57 Cooper S Convertible, JCW Convertible 2011 – 2012 2,192 Oct 28, 2010 – Sep 23, 2011
R58 Cooper S Coupe, JCW Coupe (2 Seater) 2012 420 Jun 22, 2011 – Sep 23, 2011
R59 Cooper S Roadster, JCW Roadster (2 Seater) 2012 10 Aug 11, 2010 – Sep 21, 2011
R60 Cooper S Countryman, Cooper S Countryman ALL4 2011 – 2012 9,669 Jan 19, 2011 – Sep 30, 2011

 

Q2. What is the specific issue?
The issue involves the electric auxiliary water pump on the models equipped with 4-cylinder turbocharged engines (MINI) and 8- and 12-cylinder turbocharged engines (BMW).  The auxiliary pump is controlled electronically by an engine control unit. After switching off the engine, the electric auxiliary water pump conducts heat away from the turbocharger.

Under certain conditions, the pump’s electronic circuit board can malfunction.  The malfunction can occur as a result of certain design features in combination with high operating temperatures.

 

Q3. What can happen as a result of this issue?
If the pump’s electronic circuit board malfunctions, it can overheat. In an extreme case, overheating of the circuit board can lead to smoldering of the water pump.  If smoldering occurs, it cannot be excluded that this may also lead to an engine compartment or vehicle fire.

 

Q4. This sounds familiar.  Was there a similar recall before?
Yes, the BMW Group conducted similar recalls in 2011 and 2012.

 

Q5. Why are additional models being added?
The pump supplier produced additional pumps that did not meet specifications.

 

Q6. Why are other BMW Group vehicles not included in this Safety Recall?
Other vehicles have a different electric auxiliary water pump design.

 

Q7. How did BMW Group become aware of this issue?
BMW Group became aware of this issue through its quality control procedures.

 

Q8. Can I determine if this issue exists in my vehicle? 
If you notice a plastic burning smell, or burning and/or smoke from the front of the vehicle, your vehicle may be experiencing this issue.

 

Q9. What should I do if I notice this condition in my vehicle?
Should this condition occur, pull off the road to a safe location away from traffic, and switch off the engine.  If you notice a plastic burning smell, or burning and/or smoke from the front of the vehicle, do not open the hood.  All occupants should carefully exit the vehicle and move to a location away from traffic.  Do not continue to drive your vehicle.

Contact BMW Roadside Assistance at 1-800-332-4269 or MINI Roadside Assistance at 1-866-646-4772 immediately to have your vehicle brought to the nearest authorized dealer.

 

Q10. Can I continue to drive my vehicle?
Yes.  However, when you receive a letter asking you to have this recall performed by an authorized BMW center / MINI dealer, please do so as soon as possible.  If you are not the only driver of this vehicle, please advise all other drivers of this important information.

 

Q10a. I am nervous about continuing to drive my vehicle. Can I get a loaner vehicle? Is alternate transportation available?
If you request a loaner vehicle and replacement parts are not available, we have directed our authorized BMW centers / MINI dealers to assist customers with alternate transportation needs.

 

Q11. Should I park my car in the garage, because this condition can occur when the engine is off? The BMW Group recommends parking your vehicle outdoors until repairs have been performed.

 

Q12. How will my vehicle be repaired?
The electric auxiliary water pump will be replaced on your vehicle.

 

Q13. Is BMW Group aware of any accidents, injuries or fires involving these BMW Group vehicles associated with this Safety Recall?
There are no known accidents or injuries associated with this Safety Recall.  While the number of fires has not been confirmed, a limited number may be related to this issue.
Q14. How will I be informed of this Safety Recall?
You will receive a letter in June via First Class mail advising you of this recall.  Depending upon vehicle model and parts availability, this letter may request you to schedule an appointment with an authorized BMW center / MINI dealer to have this recall performed.  In cases where parts are not immediately available, you will receive a second letter when parts become available, advising you to schedule an appointment with an authorized BMW center / MINI dealer at that time to have this recall performed.  You can locate your nearest authorized BMW center at www.bmwusa.com/dealers or authorized MINI dealer at www.miniusa.com/dealer.

To ensure the BMW Group has your most recent contact and vehicle information, please register your vehicle at www.bmwusa.com/myBMW or https://ol.miniusa.com/.  Registration is free, and will give you access to factory initiated campaigns and other information specific to your vehicle.

 

Q15. How long will the repair take?
This repair will take approximately 1 hour; however, additional time may be required depending upon your dealer’s schedule.  The repair will be performed for free by your authorized BMW center / MINI dealer.

 

Q16. Do I have to wait for my letter to have my vehicle serviced?
Yes.  We are in the process of implementing the recall campaign to ensure that the necessary parts are at the BMW centers / MINI dealers prior to sending out the owner notification letters. For the latest updates to this recall, please visit www.bmwusa.com/recall or www.miniusa.com/recall.

 

Q17. I see the “TREAD Act Customer Reimbursement Plan” attached to my letter. Can you explain what that is about? Am I eligible for reimbursement?
If you have already had this repair performed at your own expense, you may be eligible for reimbursement of certain expenses that you incurred.

 


Recall 18V – 248:  SI B11 05 18 – Alternate Transportation Measures

Enhanced Car Rental Procedure (Mid to Long-Term Alternate Transportation)

Customer requests alternate transportation while they wait for their affected vehicle to be repaired, prior to providing the customer with alternate transportation:

  • Fully complete the attached Safety Recalled BMW Vehicle Condition/Assessment Form and Self Storage Agreement(Save either as pdf or print and scan to attach to the email)
  • Within 2 days of supplying the rental vehicle, create an email with the Subject: Safety Recall Rental Request – VIN: ####### (Customer’s VIN- last seven)
  • In the body of the email, please include the start date of the rental, the part number(s) and or repair procedures that are not available and any other information that is relevant to the situation
  • Provide a center contact person’s name, phone number and email address.
  • Please send this VIN-specific email to rentalrequest@bmwna.com with the completed Safety Recalled BMW Vehicle Condition/Assessment Form and Self Storage Agreement attached for review.
  • A BMW NA representative will respond to your e-mail with instructions on how to proceed.

Alternate Transportation is Approved

Please provide the customer with a vehicle through one of our preferred third-party rental car providers (Hertz or Enterprise), BMW will reimburse the following:

BMW Rental Vehicles
  • Up to $64.00 a day; plus any
  • Market surcharge (if applicable); plus the
  • CDW* (Collision Damage Waiver) protection – when the rental vehicle agreement “signee” accepts this “optional” coverage; plus
  • Taxes
Non-BMW Rental Vehicles
  • Up to $44.00 a day; plus any
  • Market surcharge (if applicable); plus the
  • CDW* (Collision Damage Waiver) protection – when the rental vehicle agreement “signee” accepts this “optional” coverage; plus
  • Taxes

 

Invoice these allowable rental car expenses (Excluding fuel) as a separate line item on the repair order as outlined below.

Note: Aftersales Area Manager (AAM) “Field Authorization” (FAS) is not required.

Rental Vehicle Invoice – Required Information for Claim Submission

In order to be reimbursed for the above, your center must itemize the rental car invoice in the claim comments, please ensure that you always include the following information:

Rental Vehicle Invoice – Line items Required Information to be provided
Brand of rental vehicle in use BMW or Non-BMW Vehicle – Model year and description
Rental period Total number of days
Market surcharge (If applicable) Cost per day and the total amount
CDW* (Collision Damage Waiver) Cost per day and the total amount
Taxes Total amount

 


Recall 18V – 248:  SI B11 05 18 – Alternate Transportation Measures

Other Optional Protection/Insurance Coverage

BMW will only reimburse the cost of the applicable Collision Damage Waiver (CDW)* protection that the rental vehicle agreement “signee” accepted. 

*Note:  The Collision Damage Waiver (CDW), this may also be referred to as the Loss Damage Waiver (LDW) or the Physical Damage Waiver (PDW).

If your customer wants to obtain other optional protection or insurance coverage, for example:

  • SLP/SLI/LIS (Supplemental Liability Protection or Insurance/Liability Insurance Supplement); and/or
  • PAI (Personal Accident Insurance); and/or
  • PEC (Personal Effects Coverage);

The cost of this optional coverage would be at the owner’s/operator’s expense.

Important Note

If the customer believes they have access to optional protection/insurance coverage that will apply to their loaner car or rental vehicle either through their credit card company and/or personal car insurance (including other drivers and/or total loss), please encourage them to verify if and what additional coverage is available to him or her.


SI B11 05 18

November 2018

https://static.nhtsa.gov/odi/rcl/2018/RCRIT-18V248-9172.pdf

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [439.85 KB]

 


SI B11 05 18

August 2018

https://static.nhtsa.gov/odi/rcl/2018/RCRIT-18V248-1597.pdf

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [440.01 KB]

 


SI B11 05 18

April 2018

https://static.nhtsa.gov/odi/rcl/2018/RCRIT-18V248-8708.pdf

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [666.13 KB]

 


Owner Notification Letter – BMW

June 2018

https://static.nhtsa.gov/odi/rcl/2018/RIONL-18V248-8124.pdf

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [947.50 KB]

 


Owner Notification Letter – BMW

https://static.nhtsa.gov/odi/rcl/2018/RCONL-18V248-4700.pdf

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [975.58 KB]

 


Manufacturer Notices(to Dealers,etc)- April 25, 2018 – Subject: Recall 18V-248: Electronic Auxiliary Water Pump

April 25, 2018

https://static.nhtsa.gov/odi/rcl/2018/RCMN-18V248-2189.pdf

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [425.25 KB]

 


Manufacturer Notices(to Dealers,etc)- April 19, 2018 – Subject: Recall 18V-XXX: Electronic Auxiliary Water Pump

April 19, 2018

https://static.nhtsa.gov/odi/rcl/2018/RCMN-18V248-0281.pdf

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [155.39 KB]

 


Recall Acknowledgement

May 3, 2018

https://static.nhtsa.gov/odi/rcl/2018/RCAK-18V248-4385.pdf

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [240.30 KB]

 


 

Bestseller No. 1
BMW Antifreeze/coolant
  • Genuine BMW Antifreeze/Coolant
  • Part # 82141467704
  • Concentrated Dilution Required
  • Contains no nitrates or phosphates, reducing harmful deposit formation.
  • Bittering Agent Added
Bestseller No. 2
PEAK OET Extended Life Blue 50/50 Prediluted Antifreeze/Coolant for European Vehicles, 1 Gal.
  • 1 GALLON ENGINE ANTIFREEZE/COOLANT: Fully compatible with other extended life antifreeze/coolants. This item contains a bittering agent called Denatonium Benzoate.
  • PROTECTS: Advanced formulation prevents rust & corrosion protecting all cooling system components
  • DESIGNED FOR EUROPEAN VEHICLES: Recommended for use with BMW, Jaguar, Volvo, and other European vehicles that require a BLUE Silicate-Enhanced Hybrid Organic Acid Technology (Si-HOAT) formula
  • GUARANTEED: When installed as part of a complete flush and fill, PEAK guarantees this coolant will provide service life protection of up to 150,000 miles or 5 years.
  • 50/50 PREDILUTED FOR QUICK TOP OFFS: Already prediluted to make topping off your cooling system a breeze
Bestseller No. 3
MINI HT-12 High-Performance Green Coolant - Engine Protection and Efficiency - 1 Gallon - 83 19 2 468 442
  • 83 19 2 468 442
  • HT-12 GREEN COOLANT WITH BITTERING AGENT
  • Tailored to Your BMW & MINI:The HT-12 Green Coolant is exclusively formulated for the unique requirements of BMW & MINI engines, offering superior engine protection against overheating and freezing.
  • Advanced Corrosion Inhibition: Our state-of-the-art coolant technology prevents corrosion and buildup in your cooling system, ensuring it operates smoothly and extends the life of engine components.
  • Optimal Thermal Efficiency: Keep your engine running at the ideal temperature with our high-quality coolant, which ensures effective heat transfer and maintains optimal performance in extreme weather conditions.
Bestseller No. 4
Bestseller No. 5
Valvoline Multi-Vehicle 50/50 Prediluted Ready-to-Use Antifreeze/Coolant 1 GA, Light Yellow/Green.
  • CONTAINS ALUGARD PLUS FOR COMPATIBLITY WITH ALL ETHYLNE GLYCOL-BASED COOLANTS in automobiles and light duty trucks.Fit Type: Universal
  • FIGHTS CORROSION, SCALING AND RUST while protecting all cooling system metals (including aluminum)
  • HIGH-QUALITY ADDITIVES PROTECT AGAINST LEAKS and won’t harm gaskets, hoses, plastics or original vehicle finish
  • PRE-MIXED YELLOW FORMULA IS READY-TO-USE in a 50/50 ratio with deionized water to protect all modern engine components from winter freezing (-34F) and summer boiling (265F).
  • To use it in all makes and models designed to use ASTM D3306
Bestseller No. 6
Mopar 10 Year/150,000 Mile Coolant 50/50 Premixed
  • Package Weight: 4.227 kg
  • Product Type: Auto Part
  • Package Quantity: 1
  • No Batteries Required
  • Embittered - Contains Bittering Agent
SaleBestseller No. 7
Aluminum Water Hose Fitting Upgrade Fit for BMW 1 3 5 6 7 Z4 (Engine N52 N53 N54 and N51 3.0-litre),Replaces# 11537541992 11537544638 Engine Coolant Hose Flange
  • 【Compatible】This Water Hose Fitting Fits 3.0L Twin-Turbo N54 (3.0-Litre Twin Turbo) Motors 335i, 335xi, 135i and the N53 (3.0-Litre Non-Turbo) 2006 - 2010 325i, 330i, 525i, 525xi, 528i, 528xi, 530i, 530xi and the N20 (2.0-Litre Turbo) Z4 2013-, and the N52 X3.This Fitting also Suitable for N55 Motors.Please Refer to the Detailed Description or Use the Adaptation Table.
  • 【Replaces#】11537541992, 11537544638.Please Check the OEM Part Number and Make Sure Your Part Number Matches this Part Number Before Buying!
  • 【Function】Upgraded Water Hose Fitting is Made from High Strength Aluminum,Grade 6061 T6511,Durable and Wear-Resistant.
  • 【Premium Quality】100% Brand New.Made of High Quality Material. Tested & Certified to Meet or Exceed OEM Quality Standards.All Products are 100% Tested Before Leaving the Factory.
  • 【12-Month Warranty】The Automatic Transmission Filter come with 12 Months Warranty. Hassle-free Return and Refund Policy. Please Buy it with Your Confidence.
SaleBestseller No. 8
K-Seal ST5501 Multi-Purpose One Step Permanent Coolant Leak Repair, 8oz, Pour and Go, Mixes with All Antifreeze, No Flushing Required
  • Permanent Coolant Leak Repair: K-Seal’s unique formula will seek out holes and cracks, and permanently seal them, with no adverse impact on the efficiency of your engine cooling.
  • Versatile Usage: Fixes cracks and leaks in the radiator, head gasket, freeze plugs, cylinder heads, heater core, water pump casing and engine blocks
  • Universal Solution: This coolant stop leak is universally applicable. It can be used with all types of antifreeze, making K-Seal an essential tool for any vehicle owner
  • No Draining or Flushing: K-Seal coolant leak repair is easy to use. It eliminates the need for draining or flushing, making it a convenient solution. Just shake, pour and go.
  • Effective Cooling: The K-Seal 8 fluid ounce bottle is effective up to 20 quarts of cooling capacity
Bestseller No. 9
PEAK OET Extended Life Violet 50/50 Prediluted Antifreeze/Coolant for European Vehicles, 1 Gal.
  • 1 GALLON ENGINE ANTIFREEZE/COOLANT: Fully compatible with other extended life antifreeze/coolants. This item contains a bittering agent called Denatonium Benzoate.
  • PROTECTS: Advanced formulation prevents rust & corrosion protecting all cooling system components
  • DESIGNED FOR EUROPEAN VEHICLES: Recommended for use with certain years of Audi, Mercedes, Porsche, VW, and other European vehicles that require a VIOLET silicate-enhanced organic acid technology (Si-OAT) formula
  • GUARANTEED: When installed as part of a complete flush and fill, PEAK guarantees this coolant will provide service life protection up to 150,000 miles or 5 years.
  • 50/50 PREDILUTED FOR QUICK TOP OFFS: Already prediluted to make topping off your cooling system a breeze
Bestseller No. 10
PEAK Global Lifetime 50/50 Prediluted Antifreeze and Coolant for All Vehicles, 1 Gal.
  • PREDILUTED ANTIFREEZE AND COOLANT: Efficient formula is compatible with all vehicle cooling systems, providing fast-acting and long-lasting protection on all cooling system metals against rust and corrosion
  • NON-ABRASIVE FORMULA: Created with Organic Acid Technology, this ethylene glycol-based coolant formula is compatible with other antifreeze and coolant formulations. This item contains a bittering agent called Denatonium Benzoate.
  • ALL VEHICLE: Versatile and formulated for use in all American, Asian, and European automobiles including cars and low/medium to heavy duty trucks of all makes, models, and years
  • SAFE FOR FILLS AND TOP-OFFS: The amber color will not effect the antifreeze currently in your cooling system
  • LIFETIME PERFORMANCE: Provides cooling system protection for your automobile's entire lifetime with proper maintenance

Last update on 2024-03-20 / Affiliate links / Images from Amazon Product Advertising API

This product presentation was made with AAWP plugin.

1 thought on “Recall 18V-248: Electronic Auxiliary Water Pump – 2007-2012 BMW”

  1. Herb Chambers BMW in Commonwealth avenue, Boston, MA 02134, replaced the Auxiliary water pump and hose clamp due to the recall. However, 1 week later after I picked up the car, I smelled antifreeze burning, and next thing later the radiator started leaking from the top. Prior to the replacement of the auxiliary water pump, I had no issue with radiator and there was no leak. Is it possible that the parts they replaced could’ve contributed for the radiator to leak due to air pressure differential or the auxiliary water pump isn’t compatible to the radiator? I really have the feeling that this recall parts is what led to the leak to my radiator. Please comment on it if you have experienced similar problem.

    Reply

Leave a Comment

Share to...